pengenalan
This user manual provides essential information for the safe and efficient installation, operation, and maintenance of your Fantech FG4 4" Duct 135 CFM Inline Centrifugal Fan. Please read this manual thoroughly before installation and retain it for future reference.
Image: The Fantech FG4 4-inch inline centrifugal fan, featuring a silver metallic housing and a black electrical box attached to its side. This fan is designed for duct installation.
Maklumat Keselamatan
- Sentiasa putuskan bekalan elektrik sebelum menservis atau membersihkan unit.
- Pemasangan mesti dilakukan oleh juruelektrik bertauliah mengikut semua kod elektrik tempatan dan nasional.
- Do not use this fan with any solid-state speed control device unless specifically designed for it.
- Pastikan pembumian yang betul untuk mengurangkan risiko kejutan elektrik.
- Keep foreign objects away from the fan blades.
- Kipas ini untuk kegunaan dalaman sahaja.
Persediaan dan Pemasangan
The Fantech FG4 fan is designed for inline duct installation. Follow these steps for proper setup:
- Lokasi Pemasangan: Select a suitable location in the ductwork that allows for easy access for maintenance and provides adequate space around the fan for airflow. The fan can be mounted at any angle.
- Sambungan Saluran: Connect the fan to 4-inch diameter ductwork using appropriate clamps or tape to ensure an airtight seal.
- Pendawaian elektrik:
- Ensure power is disconnected at the circuit breaker before wiring.
- Connect the fan's electrical wires to the power supply according to the wiring diagram provided inside the fan's junction box cover.
- The fan operates on 12 Volts. Verify your power supply matches this requirement.
- All wiring must comply with local and national electrical codes (e.g., NEC).
- Ujian: Once installed and wired, restore power and test the fan's operation.
Arahan Operasi
The Fantech FG4 fan is designed for continuous or intermittent operation to move air through duct systems. It can be controlled via a standard wall switch or a compatible remote control system (if applicable and purchased separately).
- Hidupkan/Mati Kuasa: Use the connected wall switch or remote control to turn the fan on or off.
- Arah Aliran Udara: Ensure the fan is installed with the airflow arrow on the casing pointing in the desired direction of air movement.
- Kawalan Kelajuan: If a compatible speed controller is installed, adjust the fan speed as needed. The fan supports 3 power levels if controlled by a compatible device.
Penyelenggaraan
Penyelenggaraan berkala memastikan prestasi optimum dan jangka hayat kipas Fantech FG4 anda.
- Pemutusan Kuasa: Always disconnect power to the fan at the circuit breaker before performing any maintenance.
- Cleaning Fan Blades:
- Periodically inspect the fan blades for dust and debris accumulation.
- Carefully wipe the blades with a soft, damp kain. Jangan gunakan pembersih atau pelarut yang melelas.
- Ensure blades are dry before restoring power.
- Pelinciran Motor: The fan motor is permanently lubricated and requires no additional lubrication.
- Ductwork Inspection: Periodically check the ductwork connected to the fan for any blockages or leaks that could impede airflow.
Menyelesaikan masalah
| Masalah | Kemungkinan Punca | Penyelesaian |
|---|---|---|
| Kipas tidak beroperasi | Tiada bekalan kuasa Pendawaian longgar Kerosakan motor | Periksa pemutus litar dan suis kuasa Verify all electrical connections are secure (with power off) Contact Fantech support if motor is faulty |
| Pengurangan aliran udara | Kerja saluran tersumbat Bilah kipas kotor Incorrect fan speed setting | Inspect and clear duct obstructions Clean fan blades (see Maintenance section) Adjust speed controller if applicable |
| Kebisingan yang berlebihan | Pemasangan longgar Serpihan dalam kipas Bilah kipas yang rosak | Pastikan kipas dipasang dengan kukuh Periksa dan keluarkan sebarang serpihan Contact Fantech support if blades are damaged |
Spesifikasi
| Ciri | Perincian |
|---|---|
| Nama Model | FG4 |
| Jenama | FANTECH |
| Saiz Saluran | 4 inci |
| Kapasiti Aliran Udara | 135 Kaki Kubik Seminit (CFM) |
| Sumber Kuasa | Elektrik Bertali |
| Voltage | 12 Volt |
| Penggunaan Dalaman/Luar | Dalaman |
| Pensijilan | CSA, UL |
| bahan | Plastic (Blades), Metallic (Housing) |
Waranti dan Sokongan
Fantech products are manufactured to the highest standards and are backed by a limited warranty. For specific warranty details, please refer to the warranty card included with your product or visit the official Fantech webtapak.
For technical support, replacement parts, or warranty claims, please contact Fantech customer service:
- Webtapak: www.fantech.net
- telefon: Refer to Fantech's official webtapak untuk nombor hubungan semasa.
When contacting support, please have your product model number (FG4) and purchase date available.
